Unit 8 Petroleum Processing

1. Unit 8Petroleum Processing

2. Aims and Requirements 1. To know the constituents of petroleum in English 2. To know the petroleum processing in general • Important and Difficult Teaching Points 1. Constituents of petroleum. 2. Sentences in parallel. .

3. Questions • 1. Identify the major constituents of petroleum. • 2. List some important precursors of petrochemicals from petroleum refining. • 3. List some unit operation and conversion processes in petroleum processing. • 4. Describe briefly cracking and reforming processes.

4. A Few Terms Petroleumliterally means "rock oil". It is a very broad word referring to all liquid hydrocarbons which can be collected from the ground. Even natural gas and solid hydrocarbons are sometimes referred to as petroleum. When petroleum first comes from the ground it is called crude oil. Later it is usually just referred to as oil. It can flow like water or be as viscous as peanut butter. It can be yellow, red, green, brown, or black.

5. A Few Terms ABarrel(bbl.) of crude contains 42 gallons or 158.8 liters. No one actually ships petroleum in barrels anymore because they are too small, but the term is still used to describe a defined volume.

6. A Few Terms Natural Gasis a mixture of very low boiling hydrocarbons. Natural gas can only be liquefied under extremely high pressures and very low temperatures. It is called "dry" when methane (CH4) is the primary component, and "wet" if it contains higher boiling hydrocarbons. If it smells bad, because of sulfur compounds, it is called "sour". Otherwise, it is called "sweet". Bitumenis a another term for hydrocarbons. Both petroleum and coal are sometimes referred to as Bituminous.

7. A Few Terms Fractions are complex mixtures of chemical compounds that all have a similar boiling point. Light and heavy fractions refer to a compound's boiling point and not their actual density (these are two entirely different things). Light fractions can be very heavy (dense), and heavy fractions can be very light (go figure)! Naphtha is a light fraction of petroleum used to make gasoline. Naphtha also produces solvents and feedstocks for the petrochemical industry.

8. A Few Terms Liquefied Petroleum Gas (LPG)is a very light fraction of petroleum. It is also a fairly simple fraction containing mainly propane and butane. First, it should be noted that under normal pressures LPG is actually a gas, unlike gasoline (often just called "gas") which is really a liquid (ugh). However, under modestly high pressures these compounds can be converted to a liquid (hence their name). Being able to store them as a liquid reduces the container size by a factor of a hundred.

9. A Few Terms Gasolineis a light fraction of petroleum which is quite volatile and burns rapidly. Straight run gasoline refers to gasoline produced by distillation instead of cracking, although it really doesn't make a difference. Gasoline is often just called "gas", however it is a liquid at typical pressures. This confusing state of affairs developed because the first internal combustion engines ran on town gas (a mixture of carbon monoxide, CO, and hydrogen, H2, both actual gases). These engines were therefore called "gas engines". When gasoline replaced town gas people still called the motors "gas engines" and also started calling gasoline "gas".

10. A Few Terms Octane Numberrates a fuel's ability to avoid premature ignition called knock. Premature ignition reduces an engine's power. The octane scale arbitrarily defines n-heptane a value of 0, and isooctane (2,2,4-trimethyl pentane) an octane number of 100. Isooctane is then added to heptane until the mixture has the same knock characteristics as the fuel being tested, and the percent isooctane is taken as the unknown fuels octane number. Tetraethyl lead used to be a common anti-knock additive which would raise a fuels octane number. High octane fuel can be used in engines with high compression ratios which in turn produce much more power. However, the additive is no longer used Because of concerns over lead pollution.

11. A Few Terms Kerosenewas the first important petroleum fraction, replacing whale oils in lamps over a hundred years ago. Some unscrupulous refiners failed to distill off all the naphtha from the kerosene fraction thereby increasing the volume of their final product. This lead to many lamp explosions and fires.

12. A Few Terms Diesel Fuelsfind use in the fleet of trucks which transport the nations goods. Diesel engines power these larger engines, and use higher compression ratios (and temperatures) than their gasoline cousins. They are therefore more efficient. It is also interesting to note that diesel engines have no spark plugs, instead the fuel-air mixture is ignited by the rising temperatures and pressures during the compression stroke.

13. A Few Terms Gas Oil(or fuel oils) are used for domestic heating. In the winter refineries produce more gas oil, whereas during the summer driving months they produce more gasoline. Heavy Fuel Oilis often blended with gas oils for easier use in industry. Ships burn heavy fuel oils but they call it bunker oil. Atmospheric Residualis everything that cannot be vaporized under normal pressures. Atmospheric residual is fed into another distillation column, operating at lower pressures, which can separate out some of the lighter compounds. Lubricants and waxes reside in this fraction.

14. A Few Terms Vacuum Residualis the bottom of the barrel. It includes asphalt and some coke. Pitchis a thick, black, sticky material. It is left behind when the lighter components of coal tar or petroleum are distilled off. Pitch is a "natural" form of asphalt. Asphalt is a high boiling component of crude oil. It is therefore found at the "bottom of the barrel" when petroleum is distilled.

15. A Few Terms Tarsare byproducts formed when coke is made from coal or charcoal is made from wood. It is a thick, complex, oily black mixture of heavy organic compounds very similar to pitch or asphalt, though from a different source.

16. A Few Terms reforming n. 重整The conversion of straight-chain alkanes into branched-chain alkanes by cracking or by catalytic reaction. It is used in petroleum refining to produce hydrocarbons suitable for use in gasoline. Benzene is also manufactured from alkane hydrocarbons by catalytic reforming.转化A process used to convert methane (from natural gas) into a mixture of carbon monoxide and hydrogen, which is used to synthesize organic chemicals. The reaction is CH4 + H2O  CO + 3H2.

17. A Few Terms cracking裂化[解] Processes that cause hydrocarbon molecules to break apart into two or more smaller molecules. thermal cracking热裂解Cracking that uses high temperature (above 6500F) and long residence time to accomplish the molecular split. catalytic cracking催化裂化Cracking that accomplishes the split much faster and at lower temperatures because of the presence of a cracking catalyst.

20. 一、Words and Expressions • millennium 千年 • tubular 管式的 • still 蒸馏 • salable 可畅销的 • hydrocracking---hydrotreating • coking 结焦，焦化 • isomerization 异构化

21. gas oil 汽油，粗柴油 • heavy distillate 重馏分 • heavy mineral oil重质矿物油 • medicinal 药用的 • heavy flotation oil 重质浮选油 • lubricating oil 润滑油 • petrolatum 石蜡油 • road oil 铺路沥青

22. 二、Important sentence analysis • Petroleum, the product of natural changes in organic materials over millennia, has accumulated beneath the earth’s surface in almost unbelievable quantities and has been discovered by humans and used to meet our varied fuel wants. • 谓语并列（也可认为是句子并列）

23. The processes used include various cracking units (which make small molecules from large ones), polymerization, reforming, hydrocracking, hydrotreating, isomerization, severe processing known as coking, and literally dozens of other processes designed to alter boiling point and molecular geometry. 宾语并列

24. These relatively unstable molecules improve the antiknock quality of gasoline, although not as effectively as iso-paraffins. 句子并列

25. The processes used include various cracking units (which make small molecules from large ones), polymerization, reforming, hydrocracking, hydrotreating, isomerization, severe processing known as coking, and literally dozens of other processes designed to alter boiling point and molecular geometry. 宾语并列

26. 三、Exercises 根据课文内容将下列物质按辛烷值大小排列： n-paraffin iso-paraffin olefin aromatics

27. 科技术语构成（5） 2. 后缀 （1）构成名词的后缀 -age storage package passage usage -ance importance -ancy constancy -ant reactant refrigerant surfactant -ent solvent substituent -cide pesticide germicide -ence difference -ency efficiency

28. 科技术语构成（5） -ics electronics kinetics physics -ism mechanism stereoisomerisms -ist hemist scientist -ization polarization polymerization crystallization -ness hardness thickness -or operator donor -er worker isomer -sion conversion -tion oxidation precipitation determination -ty density safety ability

29. 科技术语构成（5） （2） 构成形容词的后缀 -al industrial essential experimental -ar molecular solar linear -ble reversible remarkable resemble -ed colored U-shaped -fold three-fold -ful useful careful successful powerful -ic dynamic asymmetric electrophilic -less useless colorless stainless -ous homogeneous heterogeneous -tive cumulative electronegative -y dusty windy cloudy

30. 科技术语构成（5） (3) 构成动词的后缀 -ate generate indicate -en harden shorten -fy simplify purify classify -ize modernize polymerize aromatize